Dedicated Subsystem WorkbenchPlatform Gen: 2022–2026

2023 Aprilia Tuareg 660 Adventure Charging System, Stator AC Output & Battery Health

Stator 3-phase AC voltage at 5,000 RPM, coil resistance, regulated DC voltage, battery code YTX9-BS (12V 8Ah), CCA rating, and multimeter charging diagnostic steps for 2023 Aprilia Tuareg 660 Adventure.

Technical PassportOEM VERIFIED

Engine

659cc

Cooling

Liquid-Cooled

Final Drive

520 Chain

Engine Oil

2.70 L (2.85 US qt)

Spark Plug

NGK MR9DE-9

Front Tire

90/90-21 (Pirelli Scorpion Rally STR)

Browse Flagship Teardowns →

Gen 2022–2026

Factory Platform Compatibility: All workshop fluid capacities, maintenance milestones, torque specifications, and consumables on this specification sheet are factory-identical across model years 2022 through 2026.

Select Model Year:(Active: 2023)
5 Production Years (2022–2026)

2022 2023 2024 2025 2026

Suggested Items3 Verified Workshop Consumables Available for this Job

View Suggested Items ↓

3-Phase Charging System & Battery Diagnostic Flowchart

Yuasa & OEM Standards

Multimeter troubleshooting protocols, cold cranking amps (CCA) ratings, 3-phase stator AC outputs, and regulator-rectifier health verification.

Shop YTX9-BS (12V 8Ah) Batteries

OEM Battery Code

YTX9-BS (12V 8Ah)

Cold Cranking Rating

Not Available

Capacity (10HR Rate)

Not Available

Regulated Output Spec

Key-OFF Parasitic Limit

Enter Multimeter DC Voltage Reading

V DC

Multimeter Test Diagnosis

Enter your multimeter terminal reading on the left to view instant diagnostic interpretations and recommended workshop actions.

OEM Factory AGM BatteryOEM Replacement

Dimensions: • Weight: Not Available. Pre-filled absorbed glass mat technology engineered for heavy vibration resistance.

Lithium LiFePO4 UpgradeUp to 70% Lighter

Features built-in RE-START jump starting reserve. Never stranded by dead lights: press the restart button on the top terminal to crank the motorcycle without jumper cables.

Smart Maintainer SpecBattery Life Extension

Standard Charge Rate: . Automated desulfation & float maintenance ensures full capacity retention during off-season winter storage.

Recommended Parts: •

Shop Smart Battery Chargers Find Direct-Fit Batteries

Aprilia Diagnostic Fault Codes & Multimeter Bench Testing

FI & OBD2 Decoder

Authentic factory ECU fault codes, sensor resistance specifications, and harness pinout troubleshooting.

Launch Full Aprilia DTC Engine→

Code P0105Manifold Absolute Pressure (MAP) Sensor

Intake air pressure sensor electrical fault or vacuum hose disconnected.

Test: Check 5.0V VRef and sensor output 2.5-3.0V at atmospheric pressure.

Code P0115Engine Coolant Temperature (ECT) Sensor

Coolant temperature sensor circuit open or shorted out of range.

Test: Measure NTC thermistor: ~2.5 kΩ at 20°C (68°F), 300 Ω at 80°C (176°F).

Code P0120Throttle Position Sensor (TPS / APS)

Ride-by-wire dual potentiometer track correlation fault.

Test: Measure APS Track 1 (0.8-4.2V) and Track 2 (0.4-2.1V); verify smooth 2:1 ratio.

Code P0335Crankshaft Position Pick-Up Sensor (CPS)

Zero timing pulses detected from VR sensor during engine cranking.

Test: Measure inductive pickup coil resistance: 560-680 Ω across 2-pin connector.

Code P0505Idle Speed Stepper Control

Idle air bypass stepper motor position error or vacuum leak.

Test: Clean stepper valve bore; perform Marelli / Bosch ECU adaptation reset.

Code P1600CAN Bus Line / Dashboard Comm Timeout

CAN communication lost between Magneti Marelli / Bosch ECU and APRC IMU / TFT Dash.

Test: Measure 60 Ω CAN termination resistance between CAN-H and CAN-L with ignition off.

Looking for other error codes, sensor pinouts, or OBD2/Euro 5 codes?

View All 68 Multi-Brand Diagnostic Trouble Codes →

Official NHTSA Safety Recalls & Technical Bulletins

0 Open Campaigns (Clean)

U.S. Department of Transportation compliance database (Title 49 U.S.C. Chapter 301).

Verify VIN on NHTSA.gov

No Active Federal Safety Recalls Reported

The U.S. DOT National Highway Traffic Safety Administration (NHTSA) records zero open safety recall campaigns for the 2023 Aprilia Tuareg 660 Adventure platform. Always check your individual 17-digit VIN at an authorized dealership or via NHTSA.gov for individual recall completions.

OEM Workshop Archives

Official Factory Service Bulletins & Field Updates

1 Documented Bulletin

Bulletin #PA2ZZQ2204Technical Service Bulletin PA2ZZQ2204: Tuareg 660 Driveline Slack Calibration & Swingarm Pivot Torque Verification

Source: PA2ZZQ2204_Tuareg660_Driveline_Manual.pdf

Mandated Torques:Rear Axle Spindle Nut (M25×1.5): 120 N·m (88.5 lb-ft)Swingarm Pivot Pin Nut: 100 N·m (74.0 lb-ft)Front Sprocket Pinion Screw (B043047): 50 N·m (37 lb-ft) (Loctite 243)Rear Sprocket Nuts (6x M10×1.25): 45 N·m (33.2 lb-ft)Chain Free Play: 35–40 mm (1.38–1.57 in) on side stand (unladen)

Consumable Specs:Castrol Chain Lube Racing Synthetic O-Ring LubricantLoctite 243 Medium-Strength ThreadlockerCastrol POWER1 ULTIMATE 4T 10W-50 Engine Oil

Genuine Part Numbers:2B008120 (520 Heavy-Duty Sealed O-Ring Chain 114 Links)B043047 (Pre-Coated Countershaft Pinion Screw M10x1.25)2B008125 (Tuareg 660 45T Rear Sprocket)2B008126 (Tuareg 660 15T Front Pinion)

OEM Chassis & Driveline EngineeringTuareg 660 Adventure Hub